Diving into electrical testing and wiring with the 948TE - Transmission Digest

Diving into electrical testing and wiring with the 948TE

We had a 2014 Jeep Cherokee come into our Bellevue, Neb. facility with a transmission that would not shift. This all-wheel drive vehicle was equipped with a 3.2L engine and a 948TE nine-speed transmission.

I was informed when the vehicle was dropped off that they previously brought it to a different shop for this same issue. Luckily for me, it was a shop that we do business with, and I know the guys over there. So, I called them first just to see if any repairs were attempted, or if they did a deep dive into diagnosing the issue. They said that they did not have any experience with nine-speeds, so they opted to refer their customer to us.

As with every other vehicle that comes in the door for diagnostics, I started off with the scan tool plugged in to check for any codes that were stored or active. I did retrieve two codes, one of which was stored and the other active.

The codes that I initially got were P0973 (shift solenoid one control circuit low) and P1DB2 (actuator supply voltage “A” circuit). The P1DB2 code was the one that was active and the one that came back right away.

I then proceeded to take the vehicle on a short road test to duplicate the customer’s concern. I found that it had harsh reverse and drive engagements, which is to be expected when in failsafe mode. When in Drive, the transmission was stuck in fourth gear and would not shift. I stopped the vehicle and shut it off so I could clear the codes to see if that would restore the correct operation. After doing that, it went right back into failsafe, indicating a current fault.

I rescanned the vehicle and retrieved only one of the two codes, which was the previously active one. I headed back to the shop for further diagnosis.

Once back at the shop, I did my normal visual inspection and battery system test. The battery looked to be in good shape and both it and the alternator were functioning correctly as well. Now, this vehicle was also equipped with the auto start-stop system, which includes an auxiliary battery. At one time I’d had another vehicle with this same setup that also had some voltage codes, and replacing the auxiliary battery fixed the issue. I went ahead and tested the auxiliary battery, and it tested just fine so I ruled that out as a cause. I did check the fluid level and condition to make sure nothing abnormal was found, and everything checked out normally.

My next step was to get some information on the codes and what criteria the TCM (transmission control module) uses to determine a fault that sets it into limp mode. I pulled up some wiring diagrams and a description of the codes. After reviewing this information, I now knew that I needed to dive into some electrical testing and needed to have the manager contact the customer to get some electrical diagnostic time approved.

After getting the customer’s approval to go ahead, I began the process. I went after the P1DB2 trouble code since that was the one that was active and came right back after clearing them. When this code sets, an open or short has been detected on the solenoid supply one, or solenoid supply two circuits. I would need to test each of these circuits in order to pinpoint a possible fault.

Armed with my wiring diagrams and testing procedures, I first checked for proper voltage supply to the transmission. On this vehicle when the case connector is disconnected and the key is turned on, it will not supply the full 12v; it defaults to approximately 2.5v. I verified on both solenoid power supply wires (SS1 & SS2) that 2.5 volts were present.

 Next, I needed to check all the internal solenoid supply #1 related circuits for an open or high resistance, which included six different solenoids. They all checked out fine. I then needed to do the same for the internal solenoid supply #2 related circuits, with only four of them on this circuit. I still didn’t find anything incorrect. Up next was checking for a short to ground on all the same circuits I just tested for an open, and I did not find anything incorrect there, either.

Read more stories in our R&R Tech series here.

Next, I disconnected the TCM and checked the wires from the TCM connector to the case connector for any opens or high resistance. Every one of the wires tested out normally. The last step in this testing procedure was to check the external solenoid low-side driver circuits for a short to ground. Once again, I still got the same correct results. Now I was getting a bit confused since I had proper voltage and good grounds with no excessive resistance or shorts.

I’ve learned from my experience that intermittent electrical problems don’t just resolve themselves. Since it would set the code and go into failsafe right away, I knew I was missing something in my process.

I decided to plug everything back in and look over the scan data. Well, wouldn’t you know it, the transmission was no longer in failsafe, so I decided to take it on a drive, thinking maybe I needed to get it hot again. It worked totally fine on the test drive. I thought to myself, how could this be?

I brought it back in to look over everything I touched, knowing I moved the harness around during testing. I looked very closely at the main harness from the TCM to the case connector (which is buried and a little hard to access the entire thing), and I found a spot in the harness that looked odd. Keep in mind, I didn’t see anything out of place or any bolts that looked to have been touched recently, but I did see this bracket right next to the harness that was a little close to it. (See Figure 1, above).

I removed the bracket and pulled the harness all the way up and found the solenoid supply #2 wires looked to have been rubbing on this bracket. I cut the split loom a bit to verify, and sure enough, that was where the issue was located. (See Figure 2).

RR-Tech-June-FIG-2-1400
Figure 2.

I repaired the wire and the vehicle performed normally after that. Since that time, I have had three other vehicles come in that were the same year and model and each of them had that same bracket starting to rub through, but none of them had ever set any codes or been in failsafe. I just loosen the bolt holding the bracket and reposition it whenever I see one of these come in.

As with most intermittent concerns, the culprit was a hidden wiring issue. In my experience, wiring harness chafing or erosion is the top cause for these concerns. Take your time, be thorough, and be the hero.

Paul Loch is a Diagnostician with Certified Transmission, and an ASE Master Certified Technician. He has been with Certified Transmission since 2010, and currently works at the Bellevue, Neb. location.

You May Also Like

Don’t fear customer complaints about CVTs

Continuously Variable Transmissions, or CVTs, are more common than you think. Audi, Subaru, Nissan, Ford, GM and many other automakers use CVT transmissions in cars and SUVs. There is no way to avoid them. Chances are there is one in your shop right now. What does CVT mean for technicians? On the maintenance side, a

CVT-Transmission-2

Continuously Variable Transmissions, or CVTs, are more common than you think. Audi, Subaru, Nissan, Ford, GM and many other automakers use CVT transmissions in cars and SUVs. There is no way to avoid them. Chances are there is one in your shop right now.

What does CVT mean for technicians? On the maintenance side, a CVT requires more or the same frequency of fluid and filter changes as a conventional automatic transmission, and many of the basic procedures are the same. On the diagnostic side, a CVT is less complicated internally than a six- or nine-speed transmission. Diagnostics with a scan tool are about the same. On the service side, while you may never pull a variator or belt out of a CVT, you can service components like sensors, pumps and valve bodies. The point here is not to fear a customer complaint about a CVT. 

A guide to common GM, Ford and Nissan programming issues

One of the most common complaints I hear from shops when trying to install a new GM TCM is, “The module will not communicate.” While that might be partially true, by design they won’t communicate until they are programmed. If programming fails, there will be an “E” code set which will help you get to

Going the extra mile: Proving your transmission repair suspicions

A 2003 Honda Pilot with a five-speed three-shaft transmission came into our shop with a customer concern that the vehicle had no power, and the “D” light was flashing. I first did a scan for codes to see what it came up with, and the scan tool returned four DTCs: P1298 (ELD voltage high), P0135 (H02S

RRfeature-1400
Hidden problems: Three tales of electrical issues

In this article, I will discuss some vehicles with electrical issues. These issues were previously addressed by a different shop/tech, but the improper or incomplete repair resulted in these hidden problems that would appear later. Related Articles – Top 20 Tools and Products: The Winners – Performance supplier listings 2024 – Shift Pointers: What to

How reading through service bulletins can turn a technician into the customer’s hero

Over the last 28 years of being a technician, I have developed the habit of checking for and reading technical service bulletins at the forefront of the diagnostic process, especially when an unfamiliar vehicle exhibiting blatant or straightforward concerns comes into the shop. I have found many valuable nuggets of information while reading over these

Other Posts

Think pink: Curtis Price strikes out on his own and has Liberty Transmission and Auto Care stand out from the crowd

In 2018, Curtis Price, at 43 years old, found himself at a crossroads in his career in the transmission industry: unsure whether he could move up in the family business where he had worked for 20 years, or whether he should start his own. At the time he was working at Price’s Transmission in Virginia

Liberty-Transmission
Easy TH400, 4L80-E reverse servo setup: Craft your own tool

While not as sensitive as some shifting bands, the Reverse band adjustment on a TH400 or 4L80-E transmission is critical, and failure to get it right has tripped up even the best builders. There is nothing worse than getting the transmission installed, putting it in Reverse and then not going anywhere or having no engine

Outgrowing the walls: The story of EVT Transmission Parts

There’s an interesting business, one of our industry’s success stories, located in the greater Los Angeles area city of Compton, CA. Walter Quintanilla is the owner of EVT Transmission Parts, which supplies a full line of parts and supplies to rebuilders in the area and beyond. The company began as a Los Angeles transmission shop

January-cover2-1400
Spotting different 68RFE designs through the years to avoid issues

The Chrysler 68RFE has had several changes through the years. Its four-speed predecessor began with a noisy solenoid pack identified by a black colored pass-through case connector (seen in Figure 1).  Related Articles – Shift Pointers: Focused DTCs – Vote for the Top 10 Powertrain Products of 2024 – Manual clutch repair and diagnostics In