Shift Pointers: Mazda Sensitive to Pressure - Transmission Digest

Shift Pointers: Mazda Sensitive to Pressure

A Mazda with the “SKYACTIVE” FW6A-EL transmission uses pressure switches to monitor the clutch application. When engagement pressure is supplied to the applicable clutch and brake, the oil pressure switch contact point closes. The TCM detects that clutch engagement pressure is supplied to the clutch/brake by opening/closing the oil pressure switch contact point.

There have been a number of these vehicles experiencing a complaint of the “Check Engine” and “A/T Warning” Lamps illuminated with the following trouble codes stored in TCM memory:

P0842 – Oil Pressure Switch #1 (pressure switch B) Stuck ON;

P0847 – Oil Pressure Switch #2 (pressure switch A) Stuck ON;

P0872 – Oil Pressure Switch #3 (pressure switch A) Stuck ON;

P0877 – Oil Pressure Switch #4 (pressure switch B) Stuck ON;

P0780 – Gear Shifting Malfunction; and

P1738 – Automatic Transmission Internal Malfunction.

This problem can be caused by contamination getting into the oil pressure switches mounted on the valve body. Although it seems that this setup is susceptible to this condition setting these codes, based on the limited amount of contamination observed, it suggests that the TCM software may be overly sensitive to setting these pressure switch codes. 

From the help given on the ATSG tech line, after programming the A/T Control Module with the latest software updates, these codes do not seem to set so quickly. This, however, does not apply to vehicles that are exhibiting any transmission problems such as delayed engagements. All transmission malfunctions must be diagnosed and repaired before updating the A/T Control Module with the latest software updates.

If pressure switches are needed, the oil pressure switch A manifold can be purchased using part number FZ01-21-2C0, while pressure switch manifold B can be purchased under part number FZ01-21-2J0. And FZ01-21-500 for a new transmission oil filter. 

When working on this, use caution when removing Oil Pressure Switch Manifold “A” to avoid damaging the ATF Temperature Sensor.

Figure 1- Pressure Switch # 1 is built into the Pressure Switch “B” Manifold – Low Clutch. Pressure Switch # 2 is built into the Pressure Switch “A” Manifold – 2-6 Clutch. Pressure Switch # 3 is built into the Pressure Switch “A” Manifold – R-3-5 Clutch. Pressure Switch # 4 is built into the Pressure Switch “B” Manifold – High Clutch.

The following vehicles seem to be susceptible to this condition:

2012 – 2013 Mazda3

2014 – 2018 Mazda3 (Japan Built with VIN starting with JM1)

2014 – 2018 Mazda3 (Mexico Built with VIN starting with 3MZ)

2013 – 2018 CX5

2014 – 2018 Mazda6

2016 – 2018 CX3

2016 – 2018 CX9

You May Also Like

Sherlock Holmes Approach to an AB60 No-Move Situation

The effectiveness in diagnosing automatic transmission malfunctions is an art form. Although there are similarities among the wide varieties of transmissions on the road, each transmission has its own peculiarities. Aside from having mechanical, hydraulic, and electrical hardware systems to contend with, software/programming issues and various vehicle platforms make diagnostics much more difficult.  Using scopes provides

ab60

The effectiveness in diagnosing automatic transmission malfunctions is an art form. Although there are similarities among the wide varieties of transmissions on the road, each transmission has its own peculiarities. Aside from having mechanical, hydraulic, and electrical hardware systems to contend with, software/programming issues and various vehicle platforms make diagnostics much more difficult. 

GM 6T40 Pump Identification Guide

The 6T40 was introduced in 2008 for General Motors front-wheel-drive cars in the Chevrolet Malibu and has gone through several changes throughout its three generations, specifically in the pump area. The 6T40 is closely related to the more lightweight 6T30 and the heavier duty 6T45 and 6T50. Generation one started phasing out during the 2012

Seeing the Forest AND the Trees

They say that the proverbial phrase “I couldn’t see the forest for the trees” means that a person or organization cannot see the big picture because it focuses too much on the details. Related Articles – 4L60E Harsh 1-2 Shift – TASC Force Tips: Diagnosing 8L45 & 8L90 Shift Complaints – TASC Force Tips: Hydraulics

The Manifold Pipeway

The Honda six-speed transmission has been on the bench of many specialty shops for one reason or another (figure 1). But, for those of you who have yet to lay your hands on one, mounted on the upper side of the unit is one of the largest, if not the largest solenoid and pressure switch

8L90 Vacuum Testing

Below are the diagrams for vacuum testing GM 8L90 transmissions. Note: OE valves are shown in rest position and should be tested in rest position unless otherwise indicated. Test locations are pointed to with an arrow. Springs are not shown for visual clarity. A low vacuum reading indicates wear. For specific vacuum test information, refer

Other Posts

Ford 8F35 maintenance tips: Planetary failure and no-pressure conditions

Our shop has had several vehicles come in with the Ford 8F35 transmission having planetary failure. Apparently, there was a run where the pinion needle bearings had a hardness problem (see Figure 1). Related Articles – Watch out for high pressure in GM 8L45, 8L90 valve bodies – A part for every need: Hard parts supplier

Figure 12.
Shift Pointers: A Chrysler 300 no-shift complaint

The case study has to do with a 2009 Chrysler 300 C 5.7L Nag1 RWD with 71,923 miles on it (see Figure 1, above). Related Articles – Back with force: ATSG is back in full swing to educate the transmission industry – Don’t fear customer complaints about CVTs – 2024 State of the Powertrain Industry

Shift Pointers: What to do when the 62TE TRS tab breaks

How frustrating it is when on a hot summer day, as you go to open a nice cold can of your drink of choice, and the tab breaks off? You are outside, away from any tools to remedy the problem quickly. It now requires a MacGyver mentality looking around at the resources available to get

Shift Pointers: Failures caused by incorrect tire sizes

For years ATSG has produced a wide range of issues related to improper tire sizes on vehicles. Even under-inflated tires have been known to cause issues. Problems such as premature failure with an active 4WD transfer case will occur with incorrect tire sizes. Related Articles – Sometimes, a diagnostic code is all you need –

Shift-Pointers-Jan-Figure-1-1400